Product ID:725 NICKEL ANTI-SEIZE COMPOUND (BULK/PRESSU
MSDS Date:12/15/1988
FSC:8030
NIIN:00N015132
MSDS Number: BKPVT

A W CHESTERTON CO

225 FALLON RD MIDDLESEX IND PK
STONEHAM, MA 02180-2999
US

Emergency Phone: 617-438-7000; 617-438-7013

Info Phone: 617-438-7000

Cage: 71431

CHESTERTON A W CO

STONEHAM, MA 02180-9101 US

Telephone: 781-438-7000/800-535-5053

Cage: 71431

NICKEL (SARA III)

CAS: 7440-02-0

RTECS: QR5950000

Fraction By Weight: 25-30%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3; 9192

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 1-3%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

ALUMINUM (SARA III)

CAS: 7429-90-5

RTECS: BD0330000

Fraction By Weight: 5-10%

OSHA PEL 15MG/M3 DUST/5 FUME

ACGIH TLV: 10MG/M3 DUST; 9192

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:HIGH VAPOR CONCENTRATIONS &
DIRECT CONTACT MAY CAUSE EYE & RESPIRATORY TRACT IRRIT.
CHRONIC:PRLNGD/RPTD SKIN CONTACT MAY DEFAT SKIN & CAUSE MINIMAL TO
SLIGHT SKIN IRRIT. NTP HAS LISTED NICKEL PO WDER AS POTNTL
CARCINOGEN BASED ON INHAL STUDIES. IARC CONSIDERS CERTAIN FORMS OF
NICKEL TO BE (SEE EFTS OF OVEREXP)
Explanation of Carcinogenicity:NICKEL:NTP-GROUP 2, IARC-GROUP 1.
Effects of Overexposure:HLTH HAZ:CANCER CAUSING BUT HAS NOT PUBLISHED A
LIST OF SPECIFIC NICKEL COMPOUNDS. NICKEL IN THIS PRODUCT IS NOT IN
POWDER FORM & SHOULD NOT PRESENT A HAZARD IN NORMAL USE (MFR).
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP. CALL
MD. EYE:FLUSH FOR AT LEAST 15 MIN W/LARGE AMOUNTS OF WATER. CALL MD
IF IRRIT PERSISTS. SKIN:WASH W/SOAP & WATER. INGEST:DO NOT INDUCE
VOMI TING. CALL MD IMMEDIATELY.

Flash Point Method:OC
Flash Point:320F,160C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM OR WATER FOG.
Fire Fighting Procedures:COOL EXPOSED CONTAINERS W/WATER. RECOMMEND
FIREFIGHTERS WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:PRESSURIZED CONTAINERS WHEN HEATED ARE
POTENTIAL EXPLOSIVE HAZARD.

Spill Release Procedures:SCOOP UP & PLACE IN SUITABLE CONTAINER FOR
DISPOSAL. KEEP OUT OF SEWERS, STREAMS & WATERWAYS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:AS IS GOOD WORK PRACTICE WHILE USING ANY HYDROCARBON,
AVOID EATING, DRINKING & SMOKING IN WORK AREA.

Respiratory Protection:NOT NORMALLY NEEDED. IF PEL/TLV IS EXCEEDED, USE
NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR FOR MISTS.
Ventilation:NO SPECIAL REQUIREMENTS. IF PEL/TLV IS EXCEEDED, PROVIDE
ADEQUATE VENTILATION.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NONE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

HCC:N1
Vapor Pres:SEE INGRED
Vapor Density:>1 (AIR=1)
Evaporation Rate & Reference:<1 (ETHER = 1)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:NEG

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS LIKE LIQUID CHLORINE AND CONCENTRATED OXYGEN.
Stability Condition to Avoid:OPEN FLAMES, HEAT, SPARKS AND RED HOT
SURFACES.
Hazardous Decomposition Products:CO, CO*2 AND OTHER OXIDES.

Waste Disposal Methods:PRODUCT SHOULD BE DISPOSED OF AS HAZARDOUS
WASTE. CHECK LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.